Engineering
Terms
undefined, object
copy deck
- GIVES ALL THE CORE INFORMATION ABOUT THE ENGINE.
- DATA PLATE
- WHAT INFORMATION DOES THE DATA PLATE CONTAIN?
-
DATE MANUFACTURED TIMING
DISPLACEMENT FIRING ORDER
VALVE CLEARANCE LOW RPM(IDLE)
HP SERIES # - WHAT IS THE LOCATION OF THE DECK PLATE?
- NEXT TO THE FUEL LINE PUMP
- DESCRIBE THE EXPANSION TANK.
- CONTAINS 50/50 MIX OF DIS. H20 AND AF. HAS RADIATOR CAP REGULATING SYSTEM PRESSURE TO 15 PSI
- THE COOLANT TEMP SOUNDS AT WHAT TEMPERATURE?
- 205 DEGREES
- WHAT DOES THE THERMOSTAT DO?
- REGULATES THE HEAT OF THE COOLANT FROM 181 - 201 DEGREES.
- PURPOSE OF THE OVERFLOW TANK?
- ALLOWS EXPANSION IN THE SYSTEM
- AIR FILTER
- PREVENTS PARTICLES FROM ENTERING AND DAMAGING THE ENGINE.
- TURBO CHARGER
- INCREASES HP OF ENGINE BY MEANS OF FORCE INDUCTION
- INTAKE VALVES
- METERS THE FLOW INTO THE ENGINES
- CYLINDER
- WHERE COMBUSTION OCCURS TURNING INTAKE AIR INTO EXAUST AIR
- EXHAUST VALVES
- CONTROLS THE FLOW OF AIR LEAVING THE CYLINDER
- EXHAUST MANIFOLD
- DIRECTS THE FLOW OF EXHAUST LEAVING THE CYLINDERS
- TURBINE SIDE
- TRANSFERS THE MOTION TO THE COMPRESSOR SIDE BEFORE THE INCREASE OF HP GOES TO THE ELBOW
- EXHAUST ELBOW
- ACTS LIKE A MUFFLER TO OVERBOARD
- RAW WATER SYSTEM
- ACTS AS A MUFFLER THEN GOES OVERBOARD?
- SUMP
- OIL PAN 13-16 QUARTS
- PUMP
-
GEAR DRIVEN
30-65 PSI OPERATING PRESSURE
MIN OIL PRESSURE 10 PSI
LOW OIL PRESSURE ALARM 8 PSI - COOLER
- PLATE TYPE. HAS 7 PLATES
- PRESSURE REGULATING VALVE
- REGULATES SYSTEM PRESSURE TO 65 PSI
- OIL FILTER
- FILTERS OUT ANY SEDIMENT IN OIL
- OIL FILTER BYPASS
- WORKS ON A 20 PSI DIFFERENTIAL
- FUEL TANK
- 200 GALLON (ONLY FILL 80%)
- FUEL WATER SEPARATOR
- 30 MICRON FILTERS (RAYCOR)
- FUEL LIFT PUMP
- KEEPS 18-25 PSI FOR FUEL SYSTEM
- FUEL FILTER
- KEEPS OUT SEDIMENT
- FUEL INJECTION PUMP
- PRESSURIZED FUEL FROM 3000-4000 PSI (NIPPON DENSO MAKER)
- HIGH PRESSURE LINES
- INJECTION NOZZEL
- FUEL INJECTION NOZZLES
- ATOMIZE FUEL ENTERING SYSTEM
- FUEL DRAIN MANIFOLD
- GOES BACK TO TANK
- SUCTION VALVE
- HAS TO BE OPEN. IT IS THE MAIM VALVE FOR SEA WATER
- STRAINER
- BASKET STRAINER (SIMPLEX)
- SALT WATER PUMP
-
GEAR DRIVEN
HAS A RUBBER IMPELLER - AFTER COOLER
- INTERACTS W/ AIR TO INCREASE HP
- TRANSMISSION COOLER
-
REMOVES HEAT FROM TRANS LUBE OIL
COOLS LUBE OIL IN TRANNY - HEAT EXCHANGER
- SEA WATER FLOWS AROUND TUBE AND COOLS
- TYPE OF OUTDRIVE
- KONRAD 520 OUTDRIVE
-
ENGINE OIL
TRIM AND TILT
POWER STEERING
FUEL -
15 W 40
DEXTRON 3
DEXTRON 3
DFM(F76)/ LAST RESORT JP5 -
TRANSMISSION OIL
ENGINE OIL
KONRAD 520 OUTDRIVE -
40W
15 W 40
75 W 90 SYNTHETIC - WHAT IS LOCATED ON THE 12V PANEL?
-
CABIN LIGHTS
MARINE BAND RADIO
SEATS
ANCHOR LIGHTS - WHAT IS THE BOTTOM OF THE BOAT PAINTED WITH?
- ANTI FOWLING PAINT
- WHAT IS LOCATED ON THE BOTTOM OF THE FUEL TANK?`
- STRIKE PLATE
- REFUELING
-
MIN FUEL TO OPERATE 50%
200 GAL TANK
FILL TO 180
STOP AT 170 SOUND AND THEN FILL TO 180 (OR 10 GAL SHORT) - FIRE BUOY SYSTEM WILL ACTIVATE HOW AND AT WHAT TEMP
- FIRE BUOY HAS A DEFUSABLE LINK THAT GOES OFF AT 185 DEGREES
- FIRE BUOY SYSTEM CHARACTERISTICS`
-
42.2 LB BOTTLE
AGENT = 241
20 LBS OF AGENT - FIRE BUOY SYSTEM
-
ALARM SOUNDS/
SECURE POWER
CLOSE ALL HATCHES
WET 2 BLANKETS AND COVER VENTS - DESCRIBE MG-5075 TRANSMISSION
-
REVERSE AND REDUCTION MARINE TRANS OFFERING HELICAL GEARING FOR QUIETER OPERATION
TWIN DISC GEARS
SINGLE SPEED REDUCTION 0.8:1 - DESCRIBE MG-5075 TRANSMISSION2
-
MAX RPMS FOR SHIFTING 800 RPM
(MUST SHIFT AT IDLE)
OIL TYPE: SAE 40
CAPACITY: 4.8 LITERS
CHANGE OIL AFTER 50 HOURS OR BREAK IN PERIOD AFTER EACH 1000 -
Length boat
Beam(-sponson tube)
Draft
Crew/ Equipment -
34ft
10ft
25"
2000lbs -
SPEED
DISPLACEMENT
PROPULSION ENGINE RATING
ELECTRICAL SYSTEM -
35 KNOTS
17,600
380 HP
24VDC -
MARINE GEAR
1) TYPE
2) MANUFACTURER -
1) MG5075 SC
2) TWIN DISC - HULL CONSTRUCTIOIN
- DEEP VEE, WELDED ALUMINUM ALLOY
- PANEL A (OVERHEAD)
-
12VDC FATHOMETER
MARINE BAND RADIO
GENTEX(INTERCOM SYSTEM)
COCKPIT/CABIN LIGHTS/ FAN - PANEL B (STBD CONTROL CONSOLE)
-
SEARCH LIGHT
ENGINE ROOM LIGHT
WIPERS
DEFROSTER
HORN/ RADAR/ RUNNING NAV LGHTS
ANCHOR LIGHTS
STROBE/ GPS
LOUD HAILER - PANCEL C (PORT SIDE)
-
ANTENNA AMP
SPEAKERS (INTERCOM)
SPARES -
YOU ARE MANNING THE M60.
COXAIN GIVES ORDER "WEAPONS READY"
WHAT WPS COND/LEVEL ARE YOU IN? -
COND. 3 WEAPON
SAFETY OFF
ROUNDS ON FEED TRAY
BOLT FWD
CHAMBER EMPTY
LEVEL 2 -
YOU ARE MANNING THE M60
COXAIN GIVES ORDER "SURFACE ACTION"
WHAT WPS COND/LEVEL ARE YOU IN? -
COND 1 WEAPON
ROUND IN FEEDTRAY ANDCHAMBER
BOLT TO THE REAR
LEVEL 1 -
YOU ARE MANNING THE M60
COXAIN GIVES ORDER "WEAPONS READY" WHAT DO YOU DO"? -
WEAPON ON FIRE
LOAD FEED TRAY WITH AMMO (1 CLICK)
RELEASE PIN FROM MOUNT
TAKE POSITIVE CONTROL OF WEAPON -
YOU ARE MANNING THE M60
COXAIN GIVES THE ORDER
"SURFACE ACTION"
WHAT DO YOU DO? -
PULL BOLT TO THE REAR MAKING A CONDITION ONE WEAPON
TRAIN WEAPON ON TARGET -
YOU ARE MANNNING THE 50 CAL
COXAIN ORDERS "WEAPONS READY"
WHAT CONDITION AND LEVEL ARE YOU IN? -
CONDITION THREE
WEAPON ON SAFE
BOLT TO REAR
AMMO ON FEED TRAY
CHAMBER EMPTY
LEVEL 2 -
YOU ARE MANNNING THE 50 CAL
COXAIN ORDERS "SURFACE ACTION"
WHAT CONDITION AND LEVEL ARE YOU IN? -
CONDITION ONE
BOLT TO THE REAR
AMMO ON FEED TRAY
ROUND IN CHAMBER
LEVEL 1 -
YOU ARE MANNNING THE 50 CAL
COXAIN ORDERS "SURFACE ACTION"
WHAT DO YOU DO? -
WEAPON ON FIRE
RACK BACK (BOLT FWD AND REAR)
TRAIN WEAPON ON TARGET -
YOU ARE MANNNING THE 50 CAL
COXAIN ORDERS "WEAPONS READY"
WHAT DO YOU DO? -
WEAPON ON SAFE
LOAD AMMO ON FEED TRAY
TAKE POSITIVE CONTROL OF WEAPON -
M60
1) AMMO
2) MER
3) MR -
AUTOMATIC/ BELT FED/ AIR COOLED
1) 7.62 MM
2) 1100 M
3) 3,725 M
OPEN BOLT FIRING WEAPON -
50 CAL
1) MER
2) MR -
1) 2000 YDS
2) 6800 YDS -
MASTHEAD WHITE LIGHT
STBD GREEN LIGHT
PORT RED LIGHT
STERN WHITE -
225 DEGREES
112.5 DEGREES
112.5 DEGREES
135 DEGREES -
HF
VHF
UHF -
3-30 MHZ
30-300 MHZ
300-3000 MHZ - BOAT
-
6 CYLINDER
QS- QUANTUM SERIES
B
T- TURBO CHARGED AFTER COOLED
5.9 M